BQXFD - TRAFFIC LINE PAINT YELLOW, 10030 091090 A
- MSDS: BQXFD
- Manufacturer: PRATT AND LAMBERT
- Product Name: TRAFFIC LINE PAINT YELLOW, 10030 091090 A
- National Stock Number: 8010-00N038165
Product Identification
Product ID:TRAFFIC LINE PAINT YELLOW, 10030 091090 A
MSDS Date:09/29/1992
FSC:8010
NIIN:00N038165
MSDS Number: BQXFD
Responsible Party
BUFFALO, NY 14240
US
Emergency Phone: 716-873-8000;800-255-3924
Info Phone: 716-873-8000
Cage: 61196
Contractor
Telephone: 216-566-2902
Cage: 61196
Ingredients
1.46 LB/GAL LESS WATER & NPRS.
RTECS: 9999999VO
Fraction By Weight: SEE ING
LTD EVID OF CARCIN IN HUMAN/SUFFICIENT EVID IN
RTECS: 9999999ZZ
THE PRINCIPAL TOX EFTS OF
RTECS: 9999999ZZ
ACIDOSIS. ETHANOL IS ANTIDOTAL & ITS EARLY
RTECS: 9999999ZZ
OF ETHYLENE GLYCOL IN THE LIVER. ETHANOL SHLD BE
RTECS: 9999999ZZ
@ A RATE OF ABOUT 10ML ETHANOL PER HR. A DESIRED
RTECS: 9999999ZZ
IN A NUMBER OF PATIENTS FOLLOWING POISONING
RTECS: 9999999ZZ
DETERMINED, BUT IT APPEARS TO BE NON-CARDIOGENIC IN
RTECS: 9999999ZZ
VENTILATION AND POSITIVE END-EXPIRATORY PRESSURE
RTECS: 9999999ZZ
EXPOSURE LIMITS WHICH MAY BE LISTED IN INGRED SECTION.
RTECS: 9999999ZZ
15%
CAS: 107-21-1
RTECS: KW2975000
Fraction By Weight: 5%
OSHA PEL 50 PPM, C
ACGIH TLV: 50 PPM,VAPOR, C
EPA Report Quantity: 1 LB
DOT Report Quantity: 1 LB
DIATOMACEOUS EARTH; (SILICA, AMORPHOUS-DIATOMACEOUS EARTH)
CAS: 68855-54-9
Fraction By Weight: 5%
OSHA PEL 10 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
SILICA, CRYSTALLINE - QUARTZ
CAS: 14808-60-7
RTECS: VV7330000
Fraction By Weight: 15 - 25%
OSHA PEL SEE TABLE Z3
ACGIH TLV: 0.1 MG/M3 RDUST;9293
PROPIONIC ACID, 2-METHYL-, MONOESTER WITH
CAS: 25265-77-4
RTECS: UF6000000
Fraction By Weight: < 5%
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:INGEST: SWALLOWING OF ETHYLENE GLYCOL
MAY CAUSE ABDOMINAL DISCOMFORT OR PAIN, DIZZINESS, MALAISE, LUMBAR
PAIN, OLIGURIA, UREMIA, & CNS DEPRESSION. SEVERE KIDNEY DAMAGE
FOLLOWS THE SWALLOWING OF LRG VO L OF ETHYLENE GLYCOL. MAY BE
FATAL. INHAL: MAY CAUSE RESPIRATORY IRRIT. EYE: MAY CAUSE EYE
IRRITATION. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:CRYSTALLINE SILICA (QUARTZ): ANTICIP TO
BE A CARCIN (NTP 6TH ANN RPT 1991), IARC GRP 2A (VOL42,P39,1987).
Effects of Overexposure:HLTH HAZ: SKIN: MAY CAUSE DEFATTING AND
IRRITATION OF THE SKIN. REPEATED & PROLONGED OCCUPATIONAL OVEREXP
TO CRYSTALLINE SILICA MAY CAUSE SILICOSIS, A PROGRESSIVELY
DISABLING LUNG DISEASE. ETHYLENE G LYCOL HAS BEEN SHOWN TO PRODUCE
DOSE-RELATED BIRTH DEFECTS IN RATS & MICE WHEN GIVEN BY MOUTH AT
HIGH CONCS. (SUPP DATA)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESP CONDITIONS MAY BE
AGGRAVATED BY EXPOSURE TO CRYSTALLINE SILICA.
First Aid
First Aid:INGEST:IMMED GIVE 1-2 GLASSES OF WATER & CALL A POIS CTRL
CTR, HOSPITAL EMER ROOM, OR MD FOR WAY TO INDUCE VOMIT. (NEVER GIVE
ANYTHING BY MOUTH TO AN UNCON PERSON). INHAL: REMOVE TO FRESH AIR.
EYE: FL USH W/LRG AMTS OF WATER FOR @ LST 15 MIN, LIFTING UPPER &
LOWER LIDS OCCSNLY. GET MED ATTN. SKIN:REMOVE CONTAM CLTHG. WASH
AFFECTED AREA W/SOAP & WATER. OBTAIN MED ATTN IF IRRIT
PERSISTS.(ING 7)
Fire Fighting
Flash Point:232F,111C
Lower Limits:ING 1
Upper Limits:ING 1
Extinguishing Media:CLASS B FIRE EXTING (CARBON DIOXIDE ALL PURPOSE DRY
CHEM/ALCOHOL FOAM) DESIGNED TO EXTING FLAMM LIQ FIRES. (SUPP DATA)
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA AND FULL PROT
EQUIP . WATER MAY BE INEFTIVE, BUT MAY BE USED TO COOL EXPOSED
CNTNRS TO PREVENT PRESSURE BUILD-UP (SUPP DATA)
Unusual Fire/Explosion Hazard:DURING EMERGENCY CNDTNS, OVEREXP TO
DECOMP PRODS MAY CAUSE A HEALTH HAZARD. SYMPTOMS MAY NOT BE
IMMEDIATELY APPARENT. OBTAIN MEDICAL ATTENTION.
Accidental Release
Spill Release Procedures:CONFINE IN SMALL AREA; USE ABSORBENT TO CLEAN
UP. PLACE IN CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:PROTECT FROM FREEZING OR EXTREMELY
HIGH TEMPERATURES.
Other Precautions:DO NOT TAKE INTERNALLY. CLOSE CONTAINER AFTER EACH
USE. DO NOT BREATHE SANDING DUST. EYE PROTECTION: WEAR SAFTY GLASES
W/SIDE SHIELDS. WEAR FACESHIELD, AS NECESSARY, WHEN SPRAYING.
Exposure Controls
Respiratory Protection:IF APPLIED BY SPRAYING, USE AN APPROPRIATE,
PROPERLY FITTED NIOSH/MSHA APPROVED RESPIRATOR TO REMOVE THE SPRAY
MIST. REFER TO OSHA 29 CFR 1910.134 " RESPIRATORY PROTECTION".
Ventilation:PROVIDE LOC EXHST VENT IN SUFF VOL & PATTERN SO AS TO
MAINTAIN EXPOS BELOW NUISANCE DUST LIMITS & PERMISSIBLE (ING 14)
Protective Gloves:IMPERMEABLE GLOVES (NEOPRENE).
Eye Protection:CHEM WORK GOGG/FULL LENGTH FSHLD .
Other Protective Equipment:EXTING MEDIA: POLYMER FOAM IS PREF FOR LARGE
FIRES.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:& POSS AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. IF
WATER IS USED, FOG NOZZ ARE PREFERABLE. EFTS OF OVEREXP:BECAUSE
THERE IS NO CURRENTLY AVAIL INFO TO SUGGEST THAT ETHYLENE GLYCOL C
AUSES BIRTH DEFECTS IN HUMANS, IT IS CONSIDERED AN ANIMAL
TERATOGEN. IARC CONSIDERS CRYSTALLINE SILICA TO HAVE (ING 6)
Chemical Properties
Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:ING 1
Vapor Density:HVR/AIR
Spec Gravity:1.3
Evaporation Rate & Reference:SLOWER THAN DIETHYL ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:59
Stability
Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:AVOID EXCESSIVE HEAT (>115F, >46C) AND
SOURCES OF IGNITION.
Hazardous Decomposition Products:BURNING, INCLUDING WHEN HEATED BY
WELDING OR CUTTING, WILL PRODUCE SMOKE, CARBON MONOXIDE AND CARBON
DIOXIDE.
Disposal
Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL LAWS. AS PRODUCED THIS PRODUCT IS NOT A WASTE. IF DISCARDED
AS IS, IT IS NOT CLASSIFIED A HAZARDOUS WASTE UNDER RCRA.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.